Series 2 Land Rover Restoration Videos | DIY Tips & Repairs

Follow Us:

Overlanding in a ... year old Land Rover!

The Landy's impressive history is just the beginning.

From Vietnam war service to the modern world, this Landy has lived a life. But her next big adventure starts now: in 2027, we're driving her from Brisbane to Birmingham.

Follow the Journey

Restoration Videos - How To

Restoration Videos on our YouTube Channel

Below are some videos created while restoring our 1960 Series 2 Land Rover. As a disclaimer, these represent DIY trial-and-error procedures detailing what worked (and what didn't!).

The History of the Landy Rover

Introduction to the history of the Landy Rover

Installing the Roof

Trying to install the roof solo

Restoration Progress so Far

Feb 2025 - Walkaround tour of the Landy

Moving again after 20 years!

The Landy goes off-road!

Land Rover Wheel Alignment

Trial and error on steering tracking

Installing Side & Back Rubber Seals

Installing tough window seals

Installing Gear Lever Rubbers

Gear selector boot fitting

4WD Yellow Knob Stuck Fix

Diagnosing transfer box 4WD engagement

Installing Headlights

The Landy can see again!

How to Start The Landy Rover

Ignition and console wiring startup

The Restoration so Far

Photo montage of the rebuild

Freewheeling Wheel Flanges

Fitting original specification hubs

Door Restoration - Part 1

Teardown and rust assessment

Door Restoration - Part 2

Stripping paint and frame repairs

Door Restoration - Part 3

Painting and final skin fitting

Polarising the Dynamo

12V charging system polarity fix

Installing Rear Door Glass

Installing iconic rear windows

Installing Britpart Front Seats

Fitting replacement vinyl seats

Finally a Road Test

First drive on bitumen in 20 years!

Installing MudUK Door Cards

Fitting interior door trim inserts

Replacing the Speedo Cable

Fixing the speedometer linkage

Replacing Hub & Axle Gaskets

Fixing oil leaks on wheel bearings

Reverse Bleeding Brakes

Removing trapped air from brake lines

Restoration Complete (Almost)

Getting ready for roadworthy inspection

Replacing Propshaft Boot

Replacing split driveshaft rubber boot

Setting Valve Clearances

Adjusting tappets on 2.25 engine

Share this page with fellow Landy fans:

Do you like this page or find it useful?

Likes Total: 0

© TheLandyRover, All Rights Reserved.